motorcycle assembly preparation manual page 2 kawasaki and theirebook download kawasaki ninja r owners manual kawasaki ninja r. road, the Ninja , now with optional ABS models offers a versatile riding experience for both Adhere to the maintenance schedule in your owner’s manual. View and Download Kawasaki Ninja R service manual online. Ninja R Motorcycle pdf manual download. Also for: Ninja er-6f, Ninja er-6f abs.
|Published (Last):||13 June 2004|
|PDF File Size:||16.5 Mb|
|ePub File Size:||15.70 Mb|
|Price:||Free* [*Free Regsitration Required]|
locate a dealer
Be alert for problems and non-scheduled ticular interest for more efficient and con- maintenance. Inlet Air Temperature Sensor Ignition Fuse 10 A 7. Do not use fluid from a container that has been left unsealed or that has been open for a long time.
To facilitate manial operations, notes, illustra- tions, photographs, cautions, and detailed descriptions have been included in each chapter wherever necessary. Water-proof Joint B 5. A fully charged battery is a must for conducting accurate tests of the DFI system.
Kawasaki Ninja R Service Manual – ZX6R Forum
If the ninj is bent, dented, cracked, or warped, replace it. Air Switching Valve 2. Special Tools and Sealant If the clearance is between 0.
Replace the drain bolt gasket [B] with a new one. In addition, the nature of the fault is stored in the memory ownres the ABS hydraulic unit and when in the self-diagnosis mode, the ser- vice code [A] is indicated by the number of times the ABS indicator light LED 650f. Stick coil shorted or not in good contact Inspect or Reinstall see chapter How can cool down for engine heated? Throttle Full Open UR: Right City Light Lead Connector 5. Special Tools and Sealant Hand Tester: Ownesr Hose Replacement CAUTION When removing and installing the fuel hose joint, do not apply strong force to the outlet pipe on the fuel pump and delivery pipe on the throttle body assy.
Clamp Faces the stopper forward. Battery cable making poor contact Load excessive e.
Incorrect the tire pressure. Environment when problem occurred.
Band Hold the main harness in rear of the frame cross pipe. Front Wheel Rotation Sensor 7. Stick coil trouble Inspect see chapter Align the clamp knob with the red paint as shown in the figure. If the fuel pressure is much higher than specified, the fuel pressure regulator in the fuel pump have been clogged or stuck. Ignition Fuse 10 A 3. Brake Pipe to Front Calipers 6. Never drop the throttle body assy, especially on a hard surface.
Torque – Clutch Spring Bolts: There will be a gap [A] at the rear part of the holder after tightening. Set it close to the bottom of the cylinder, where cylinder wear is low. Kawasaki Bond Liquid Gasket – Black: Then tighten them according to the majual se- quence to prevent case warpage or deformation which can lead to malfunction.
Never reuse old brake fluid.
Kawasaki Ninja R Owner’s Manual PDF | Aaron posts things here
The relays and diodes can not be removed. Install the shim specified where the lines intersect. Circlip [D] 25 mm 0.
Illustrations and photographs in this publication are intended for reference use only and may not depict actual model component parts. Connect the connectors securely. Special Tool – Bearing Driver Set: Engine Stop Switch 3.
Fuel Pump Relay D: Starter Lockout Switch 5.
Page Page – Oxygen sensor-incorrect output voltage Torque – Lower Fairing Bracket Bolts: Headlight Lo Lead Connector 6. Tapping the shaft or body could damage the motor. Insert the clamp into the frame from the air cleaner side. Radiator Fan Circuit 1.
If there is the continuity in the lead, replace the ABS hy- draulic unit. Toothed Washer, 34 mm 1. Drive Chain Slack — — —